Abstract：Theoretical relations that predict the transition from a stratified pattern to a slug pattern, including a one-dimensional wave model that contains less empiricism than the commonly used Taitel-Dukler model, and the ideal model for stratified flow for the gas-liquid flow in horizontal pipes are presented. Superficial velocities of each phase, as the onset of slugging occurs, were predicted, and theoretical analysis was conducted on the stratified to slug flow regime transition. The friction, existing between the fluid and pipe wall, and on the interface of two phases, was especially taken into account. A theoretical model was applied to an experiment about air-oil two-phase flow in a 50 mm horizontal pipe. The effect of pipe diameter on the transition was also studied. The results show that this approach gives a reasonable prediction over the whole range of flow rates, and better agreement has been achieved between predicted and measured critical parameters.
出版日期: 2008-06-05
引用本文:
. Experimental study for the stratified to slug
flow regime transition mechanism of gas-oil two-phase flow in horizontal
pipe[J]. Frontiers of Energy and Power Engineering in China - Selected Publications from Chinese Universities, 2008, 2(2): 152-157.
LIU Yiping, YANG Weilin, WANG Jing. Experimental study for the stratified to slug
flow regime transition mechanism of gas-oil two-phase flow in horizontal
pipe. Front. Energy, 2008, 2(2): 152-157.
Kordyban E Horizontalslug flow: a comparison of existing theoriesASME J Fluids Engineering 1990 112(1)7483
2
Fabre J Line A Modeling of two-phase slugflowAnn Rev Fluid Mech 1992 242146. doi:10.1146/annurev.fl.24.010192.000321
3
Lin P Y Hanratty T J Prediction of the initiationof slugs with linear instability theoryInt J Multiphase Flow 1986 12(1)7998. doi:10.1016/0301‐9322(86)90005‐4
4
Wu H L Pots B F M Hollenberg J F et al.Flow pattern transitions in two-phase gas/condensateflow at high pressure in an 8-inch horizontal pipeThird Int Conf on Multiphase FlowHague, Netherlands 1987 1321
5
Li Guangjun Study on the characteristics of interfacial waves in gas-liquid pipeflow. Dissertation for the Doctoral DegreeXi'anXi'an Jiaotong University 1996 (in Chinese)
6
Taitel Y Dukler A E A model for predicting flowregime transition in horizontal and near horizontal gas-liquid flowAICHE J 1976 224755. doi:10.1002/aic.690220105
7
Wallis G B One-DimentionalTwo-Phase FlowNew YorkMcGraw-Hill Press 1969
8
Lin P Y Hanratty T J The effect of the pipe diameteron the flow patterns for air-water flow in horizontal pipesInt J Multiphase Flow 1987 13549563. doi:10.1016/0301‐9322(87)90021‐8
