Experimental study on the coupling effect of pore-fracture system and permeability controlled by stress in high-rank coal
Jiang HAN1,2, Caifang WU1,2(), Lu CHENG3
1. Key Laboratory of Coalbed Methane Resources and Reservoir Formation (Ministry of Education of China), China University of Mining and Technology, Xuzhou 221116, China 2. School of Resources and Geoscience, China University of Mining and Technology, Xuzhou 221116, China 3. China United Coalbed Methane Corporation, Ltd., Beijing 100016, China
During the coalbed methane (CBM) exploitation, the reservoir permeability can be affected by the effective stress that varies with the reservoir fluid pressure, which is a complex, dynamic and significant engineering problem. To analyze the response characteristics of the pore-fracture system by the changing stress, this work simulated reservoir and fluid pressures during the exploitation by adjusting confining pressure and displacement pressure. Stress sensitivity experiments under different effective stresses were conducted to systematically study the stage variation characteristics of porosity and permeability of coal. The results show that the permeability decreases exponentially with the increase in effective stress, consistent with previous studies. However, the porosity shows a V-shaped trend, which is different from the traditional understanding that it would decrease continuously with rising effective stress. These variation characteristics (of porosity and permeability above) therefore result in a phased porosity sensitivity of coal permeability (PPS). Moreover, the stress sensitivity of the samples was evaluated using the permeability damage rate method (MPDR) and the stress sensitivity coefficient method (MCSS), both of which showed that it ranges from the degree of strong to extremely strong. When the effective stress is lower than 5–6 MPa, the stress sensitivity of the coal reservoir drops rapidly with effective stress rising; when it is higher than 5–6 MPa, the change in stress sensitivity tends to flatten out, and the stress sensitivity coefficient (CSS) goes down slowly with rising effective stress. Finally, suggestions are proposed for the drainage scheme of CBM wells based on the experimental results.
. [J]. Frontiers of Earth Science, 2023, 17(1): 135-144.
Jiang HAN, Caifang WU, Lu CHENG. Experimental study on the coupling effect of pore-fracture system and permeability controlled by stress in high-rank coal. Front. Earth Sci., 2023, 17(1): 135-144.
T, Ai , S, Wu , R, Zhang , M, Gao , J, Zhou , J, Xie , L, Ren , Z Zhang . (2021). Changes in the structure and mechanical properties of a typical coal induced by water immersion. Int J Rock Mech Min Sci, 138: 104597 https://doi.org/10.1016/j.ijrmms.2020.104597
2
N, Aziz , T, Ren , J, Nemcik , L Zhang . (2013). Permeability and volumetric changes in coal under different test environment. Acta Geodyn Geomater, 10: 163–171 https://doi.org/10.13168/AGG.2013.0016
3
S, Chen , P, Liu , D, Tang , S, Tao , T Zhang . (2021a). Identification of thin-layer coal texture using geophysical logging data: investigation by Wavelet Transform and Linear Discrimination Analysis. Int J Coal Geol, 239: 103727 https://doi.org/10.1016/j.coal.2021.103727
4
S, Chen , D, Tang , S, Tao , P, Liu , J P Mathews . (2021b). Implications of the in situ stress distribution for coalbed methane zonation and hydraulic fracturing in multiple seams, western Guizhou, China. J Petrol Sci Eng, 204: 108755 https://doi.org/10.1016/j.petrol.2021.108755
5
S, Chen , S, Tao , W, Tian , D, Tang , B, Zhang , P Liu . (2021c). Hydrogeological control on the accumulation and production of coalbed methane in the Anze Block, southern Qinshui Basin, China. J Petrol Sci Eng, 198: 108138 https://doi.org/10.1016/j.petrol.2020.108138
6
Y, Chen , D, Liu , Y, Yao , Y, Cai , L Chen . (2015). Dynamic permeability change during coalbed methane production and its controlling factors. J Nat Gas Sci Eng, 25: 335–346 https://doi.org/10.1016/j.jngse.2015.05.018
7
Z, Chen , J, Liu , Z, Pan , L D, Connell , D Elsworth . (2012). Influence of the effective stress coefficient and sorption-induced strain on the evolution of coal permeability: model development and analysis. Int J Greenh Gas Control, 8: 101–110 https://doi.org/10.1016/j.ijggc.2012.01.015
8
Z, Chen , Z, Pan , J, Liu , L D, Connell , D Elsworth . (2011). Effect of the effective stress coefficient and sorption-induced strain on the evolution of coal permeability: experimental observations. Int J Greenh Gas Control, 5(5): 1284–1293 https://doi.org/10.1016/j.ijggc.2011.07.005
9
C R, Clarkson , F Qanbari . (2016). A semi-analytical method for forecasting wells completed in low permeability, undersaturated CBM reservoirs. J Nat Gas Sci Eng, 30: 19–27 https://doi.org/10.1016/j.jngse.2016.01.040
10
X, Cui , R M Bustin . (2005). Volumetric strain associated with methane desorption and its impact on coalbed gas production from deep coal seams. AAPG Bull, 89(9): 1181–1202 https://doi.org/10.1306/05110504114
Y, Geng , D, Tang , H, Xu , S, Tao , S, Tang , L, Ma , X Zhu . (2017). Experimental study on permeability stress sensitivity of reconstituted granular coal with different lithotypes. Fuel, 202: 12–22 https://doi.org/10.1016/j.fuel.2017.03.093
13
F, Gu , R Chalaturnyk . (2010). Permeability and porosity models considering anisotropy and discontinuity of coalbeds and application in coupled simulation. J Petrol Sci Eng, 74(3–4): 113–131 https://doi.org/10.1016/j.petrol.2010.09.002
14
P, Guo , Y, Cheng , K, Jin , W, Li , Q, Tu , H Liu . (2014). Impact of effective stress and matrix deformation on the coal fracture permeability. Transp Porous Media, 103(1): 99–115 https://doi.org/10.1007/s11242-014-0289-4
15
X, Guo , G, Zou , Y, Wang , Y, Wang , T Gao . (2017). Investigation of the temperature effect on rock permeability sensitivity. J Petrol Sci Eng, 156: 616–622 https://doi.org/10.1016/j.petrol.2017.06.045
16
J, Han , C, Wu , X, Jiang , X, Fang , S Zhang . (2022). Investigation on effective stress coefficients and stress sensitivity of different water-saturated coals using the response surface method. Fuel, 316: 123238 https://doi.org/10.1016/j.fuel.2022.123238
17
P, Hou , F, Gao , Y, Ju , H, Cheng , Y, Gao , Y, Xue , Y Yang . (2016). Changes in pore structure and permeability of low permeability coal under pulse gas fracturing. J Nat Gas Sci Eng, 34: 1017–1026 https://doi.org/10.1016/j.jngse.2016.08.015
18
D, Jasinge , P G, Ranjith , S K Choi . (2011). Effects of effective stress changes on permeability of latrobe valley brown coal. Fuel, 90(3): 1292–1300 https://doi.org/10.1016/j.fuel.2010.10.053
19
F O, Jones , W W Owens . (1980). A laboratory study of low-permeability gas sands. J Pet Technol, 32(9): 1631–1640 https://doi.org/10.2118/7551-PA
20
Y, Ju , Q, Zhang , J, Zheng , J, Wang , C, Chang , F Gao . (2017). Experimental study on CH4 permeability and its dependence on interior fracture networks of fractured coal under different excavation stress paths. Fuel, 202: 483–493 https://doi.org/10.1016/j.fuel.2017.04.056
21
Y, Li , D, Tang , H, Xu , Y, Meng , J Li . (2014). Experimental research on coal permeability: the roles of effective stress and gas slippage. J Nat Gas Sci Eng, 21: 481–488 https://doi.org/10.1016/j.jngse.2014.09.004
22
H, Liu , J Rutqvist . (2010). A new coal-permeability model: internal swelling stress and fracture–matrix interaction. Transp Porous Media, 82(1): 157–171 https://doi.org/10.1007/s11242-009-9442-x
23
J, Liu , Z, Chen , D, Elsworth , X, Miao , X Mao . (2011a). Evolution of coal permeability from stress-controlled to displacement-controlled swelling conditions. Fuel, 90(10): 2987–2997 https://doi.org/10.1016/j.fuel.2011.04.032
24
J, Liu , J, Wang , Z, Chen , S, Wang , D, Elsworth , Y Jiang . (2011b). Impact of transition from local swelling to macro swelling on the evolution of coal permeability. Int J Coal Geol, 88(1): 31–40 https://doi.org/10.1016/j.coal.2011.07.008
25
T, Liu , B, Lin , W Yang . (2017). Impact of matrix–fracture interactions on coal permeability: model development and analysis. Fuel, 207: 522–532 https://doi.org/10.1016/j.fuel.2017.06.125
26
W, Liu , Y, Liu , C, Niu , G, Han , Y Wan . (2015). A model of unsteady seepage flow in low-permeable coalbed with moving boundary in consideration of wellbore storage and skin effect. Procedia Eng, 126: 517–521 https://doi.org/10.1016/j.proeng.2015.11.294
27
C R, McKee , A C, Bumb , R A Koenig . (1988). Stress-dependent permeability and porosity of coal and other geologic formations. SPE Form Eval, 3(1): 81–91 https://doi.org/10.2118/12858-PA
28
Y, Meng , Z, Li , F Lai . (2015). Experimental study on porosity and permeability of anthracite coal under different stresses. J Petrol Sci Eng, 133: 810–817 https://doi.org/10.1016/j.petrol.2015.04.012
29
Y, Meng , S, Liu , Z Li . (2018). Experimental study on sorption induced strain and permeability evolutions and their implications in the anthracite coalbed methane production. J Petrol Sci Eng, 164: 515–522 https://doi.org/10.1016/j.petrol.2018.01.014
30
Z, Meng , G Li . (2013). Experimental research on the permeability of high-rank coal under a varying stress and its influencing factors. Eng Geol, 162: 108–117 https://doi.org/10.1016/j.enggeo.2013.04.013
31
A, Mitra , S, Harpalani , S Liu . (2012). Laboratory measurement and modeling of coal permeability with continued methane production: part I – laboratory results. Fuel, 94: 110–116 https://doi.org/10.1016/j.fuel.2011.10.052
32
Y, Niu , P, Mostaghimi , I, Shikhov , Z, Chen , R T Armstrong . (2018). Coal permeability: gas slippage linked to permeability rebound. Fuel, 215: 844–852 https://doi.org/10.1016/j.fuel.2017.11.082
33
N M, Özgül , M, Savaşçın , İ Özkan . (2017). Recycling of coal ash in production of low density masonry unit. Acta Phys Pol A, 132(3): 430–432 https://doi.org/10.12693/APhysPolA.132.430
34
Z, Pan , D, Connell , M Camilleri . (2010). Laboratory characterisation of coal reservoir permeability for primary and enhanced coalbed methane recovery. Int J Coal Geol, 82(3–4): 252–261 https://doi.org/10.1016/j.coal.2009.10.019
35
J, Shao , L, You , Y, Kang , X, Gao , M, Chen , S, Meng , N Zhang . (2020). Experimental study on stress sensitivity of underground gas storage. J Petrol Sci Eng, 195: 107577 https://doi.org/10.1016/j.petrol.2020.107577
36
D, Shaw , P, Mostaghimi , R T Armstrong . (2019). The dynamic behaviour of coal relative permeability curves. Fuel, 253: 293–304 https://doi.org/10.1016/j.fuel.2019.04.107
37
J Shi, S Durucan, S Shimada (2014). How gas adsorption and swelling affects permeability of coal: a new modelling approach for analysing laboratory test data. Int J Coal Geol, 128–129: 134–142 https://doi.org/10.1016/j.coal.2014.04.012
38
W H Somerton, I M Söylemezoḡlu, R C Dudley (1975). Effect of stress on permeability of coal. Intern J Rock Mechanics Mining Sci Geomechanics. Elsevier: 129–145
39
Z, Sun , X, Li , J, Shi , P, Yu , L, Huang , J, Xia , F, Sun , T, Zhang , D Feng . (2017). A semi-analytical model for drainage and desorption area expansion during coal-bed methane production. Fuel, 204: 214–226 https://doi.org/10.1016/j.fuel.2017.05.047
40
Z, Sun , J, Shi , K, Wang , Y, Miao , T, Zhang , D, Feng , F, Sun , S, Wang , S, Han , X Li . (2018). The gas-water two phase flow behavior in low-permeability CBM reservoirs with multiple mechanisms coupling. J Nat Gas Sci Eng, 52: 82–93 https://doi.org/10.1016/j.jngse.2018.01.027
41
S, Tao , S, Chen , Z Pan . (2019a). Current status, challenges, and policy suggestions for coalbed methane industry development in China: a review. Energy Sci Eng, 7(4): 1059–1074 https://doi.org/10.1002/ese3.358
42
S, Tao , S, Chen , D, Tang , X, Zhao , H, Xu , S Li . (2018). Material composition, pore structure and adsorption capacity of low-rank coals around the first coalification jump: a case of eastern Junggar Basin, China. Fuel, 211: 804–815 https://doi.org/10.1016/j.fuel.2017.09.087
43
S, Tao , Z, Pan , S, Tang , S Chen . (2019b). Current status and geological conditions for the applicability of CBM drilling technologies in China: a review. Int J Coal Geol, 202: 95–108 https://doi.org/10.1016/j.coal.2018.11.020
44
G, Wang , T, Ren , K, Wang , A Zhou . (2014a). Improved apparent permeability models of gas flow in coal with Klinkenberg effect. Fuel, 128: 53–61 https://doi.org/10.1016/j.fuel.2014.02.066
45
J, Wang , D, Tang , H, Xu , J, Yi , Y Yi . (2013). Stress sensitivity of coal samples in terms of anisotropy. J Coal Sci Eng China, 19(2): 203–209 https://doi.org/10.1007/s12404-013-0215-3
46
K, Wang , J, Zang , G, Wang , A Zhou . (2014b). Anisotropic permeability evolution of coal with effective stress variation and gas sorption: model development and analysis. Int J Coal Geol, 130: 53–65 https://doi.org/10.1016/j.coal.2014.05.006
47
S, Wang , D, Elsworth , J Liu . (2011). Permeability evolution in fractured coal: The roles of fracture geometry and water-content. Int J Coal Geol, 87(1): 13–25 https://doi.org/10.1016/j.coal.2011.04.009
48
S, Wang , H, Li , W, Wang , D Li . (2018a). Experimental study on mechanical behavior and energy dissipation of anthracite coal in natural and forced water-saturation states under triaxial loading. Arab J Geosci, 11(21): 668 https://doi.org/10.1007/s12517-018-4014-4
49
W, Wang , H, Li , Y, Liu , M, Liu , H, Wang , W Li . (2020). Addressing the gas emission problem of the world’s largest coal producer and consumer: lessons from the Sihe Coalfield, China. Energy Rep, 6: 3264–3277 https://doi.org/10.1016/j.egyr.2020.11.199
50
W, Wang , H, Wang , D, Li , H, Li , Z Liu . (2018b). Strength and failure characteristics of natural and water-saturated coal specimens under static and dynamic loads. Shock Vib, 2018: 1–15 https://doi.org/10.1155/2018/3526121
51
K, Xiao , Z, Zhang , R, Zhang , M, Gao , J, Xie , A, Zhang , Y Liu . (2021). Anisotropy of the effective porosity and stress sensitivity of coal permeability considering natural fractures. Energy Rep, 7: 3898–3910 https://doi.org/10.1016/j.egyr.2021.06.067
52
W, Xiao , T, Li , M, Li , J, Zhao , L, Zheng , L Li . (2016). Evaluation of the stress sensitivity in tight reservoirs. Pet Explor Dev, 43(1): 115–123 https://doi.org/10.1016/S1876-3804(16)30013-1
53
H, Xie , Y, Ju , F, Gao , M, Gao , R Zhang . (2017). Groundbreaking theoretical and technical conceptualization of fluidized mining of deep underground solid mineral resources. Tunn Undergr Space Technol, 67: 68–70 https://doi.org/10.1016/j.tust.2017.04.021
54
B, Xu , X, Li , W, Ren , D, Chen , L, Chen , Y Bai . (2017). Dewatering rate optimization for coal-bed methane well based on the characteristics of pressure propagation. Fuel, 188: 11–18 https://doi.org/10.1016/j.fuel.2016.09.067
55
Y, Yao , D, Liu , S Xie . (2014). Quantitative characterization of methane adsorption on coal using a low-field NMR relaxation method. Int J Coal Geol, 131: 32–40 https://doi.org/10.1016/j.coal.2014.06.001
56
J, Ye , S, Tao , S, Zhao , S, Li , S, Chen , Y Cui . (2022). Characteristics of methane adsorption/desorption heat and energy with respect to coal rank. J Nat Gas Sci Eng, 99: 104445 https://doi.org/10.1016/j.jngse.2022.104445
57
X, Zhang , C, Wu , S Liu . (2017a). Characteristic analysis and fractal model of the gas-water relative permeability of coal under different confining pressures. J Petrol Sci Eng, 159: 488–496 https://doi.org/10.1016/j.petrol.2017.09.057
58
X, Zhang , C, Wu , Z Wang . (2019a). Experimental study of the effective stress coefficient for coal permeability with different water saturations. J Petrol Sci Eng, 182: 106282 https://doi.org/10.1016/j.petrol.2019.106282
59
Y, Zhang , X, Xu , M, Lebedev , M, Sarmadivaleh , A, Barifcani , S Iglauer . (2016a). Multi-scale x-ray computed tomography analysis of coal microstructure and permeability changes as a function of effective stress. Int J Coal Geol, 165: 149–156 https://doi.org/10.1016/j.coal.2016.08.016
60
Z, Zhang , R, Zhang , S, Wu , J, Deng , Z, Zhang , J Xie . (2019b). The stress sensitivity and porosity sensitivity of coal permeability at different depths: a case study in the Pingdingshan mining area. Rock Mech Rock Eng, 52(5): 1539–1563 https://doi.org/10.1007/s00603-018-1633-8
61
Z, Zhang , R, Zhang , H, Xie , M, Gao , J Xie . (2016b). Mining-induced coal permeability change under different mining layouts. Rock Mech Rock Eng, 49(9): 3753–3768 https://doi.org/10.1007/s00603-016-0979-z
62
Z, Zhang , R, Zhang , H, Xie , M, Gao , E, Zha , Z Jia . (2017b). An anisotropic coal permeability model that considers mining-induced stress evolution, microfracture propagation and gas sorption-desorption effects. J Nat Gas Sci Eng, 46: 664–679 https://doi.org/10.1016/j.jngse.2017.08.028
63
Z, Zhang , R, Zhang , H, Xie , M Gao . (2015). The relationships among stress, effective porosity and permeability of coal considering the distribution of natural fractures: theoretical and experimental analyses. Environ Earth Sci, 73(10): 5997–6007 https://doi.org/10.1007/s12665-015-4280-3
64
Y, Zhao , S, Liu , Y, Jiang , K, Wang , Y Huang . (2016). Dynamic tensile strength of coal under dry and saturated conditions. Rock Mech Rock Eng, 49(5): 1709–1720 https://doi.org/10.1007/s00603-015-0849-0
