1. Zhuhai UM Science & Technology Research Institute, Zhuhai 519031, China 2. Department of Civil and Environmental Engineering, The Hong Kong University of Science & Technology, Hong Kong 999077, China 3. Department of Civil and Environmental Engineering, Faculty of Science and Technology, University of Macau, Macao 999078, China
● A simple and effective SUPR reactor was developed.
● Over 98% of P could be recovered without urine storage or chemical addition.
● Struvite with relatively high purity could be obtained.
● Increased urine dilution led to higher nitrification efficiency.
Leveraging seawater toilet flushing system in Hong Kong, China, a Seawater-based Urine Phosphorus Recovery (SUPR) process that integrates ureolysis and phosphorus (P) recovery was proposed in our earlier work. In this study, a thermodynamic model was applied to evaluate the effects of ureolysis and the seawater-to-urine mixing ratio (S/U ratio) on P precipitation in the SUPR system. The results suggested that effective P recovery was thermodynamically feasible across a wide range of S/U ratios, with elevated pH levels resulting from ureolysis being critical for P precipitation. Furthermore, a SUPR reactor was developed to validate this process. When the hydraulic retention time (HRT) exceeded 3 h and the S/U ratio was lower than 3:1, more than 98% of P could be recovered without urine storage, chemical dosage, or external mixing. Further decrease in the HRT and increase in S/U ratio caused flushing out of fine precipitates, resulting in a relatively low P recovery efficiency. However, this could be advantageous when downstream urine nitrification is implemented, as dilution of urine can alleviate the inhibitory effects of free ammonia and free nitrous acid, as well as overcome the P limitation problem, thus facilitating urine nitrification. Consequently, there is a trade-off between optimizing P recovery and nitrification efficiencies.
F Abbona, H E Lundager Madsen, R Boistelle. (1986). The initial phases of calcium and magnesium phosphates precipitated from solutions of high to medium concentrations. Journal of Crystal Growth, 74(3): 581–590 https://doi.org/10.1016/0022-0248(86)90205-8
2
F Abbona, H E Lundager Madsen, R Boistelle. (1988). The final phases of calcium and magnesium phosphates precipitated from solutions of high to medium concentration. Journal of Crystal Growth, 89(4): 592–602 https://doi.org/10.1016/0022-0248(88)90223-0
3
M I H Bhuiyan, D S Mavinic, R D Beckie. (2007). A solubility and thermodynamic study of struvite. Environmental Technology, 28(9): 1015–1026 https://doi.org/10.1080/09593332808618857
4
N A Booker, A J Priestley, I H Fraser. (1999). Struvite formation in wastewater treatment plants: opportunities for nutrient recovery. Environmental Technology, 20(7): 777–782 https://doi.org/10.1080/09593332008616874
5
N C Bouropoulos, P G Koutsoukos. (2000). Spontaneous precipitation of struvite from aqueous solutions. Journal of Crystal Growth, 213(3−4): 381–388 https://doi.org/10.1016/S0022-0248(00)00351-1
6
J R Buchanan, C R Mote, R B Robinson. (1994). Thermodynamics of Sstruvite formation. Transactions of the ASAE, 37(2): 617–621 https://doi.org/10.13031/2013.28121
7
X Cao, W Harris. (2008). Carbonate and magnesium interactive effect on calcium phosphate precipitation. Environmental Science & Technology, 42(2): 436–442 https://doi.org/10.1021/es0716709
8
D Cordell, J O Drangert, S White. (2009). The story of phosphorus: global food security and food for thought. Global Environmental Change, 19(2): 292–305 https://doi.org/10.1016/j.gloenvcha.2008.10.009
9
J Dai, W T Tang, Y S Zheng, H R Mackey, H K Chui, M C M van Loosdrecht, G H Chen. (2014). An exploratory study on seawater-catalysed urine phosphorus recovery (SUPR). Water Research, 66: 75–84 https://doi.org/10.1016/j.watres.2014.08.008
10
E Desmidt, K Ghyselbrecht, A Monballiu, K Rabaey, W Verstraete, B D Meesschaert. (2013). Factors influencing urease driven struvite precipitation. Separation and Purification Technology, 110: 150–157 https://doi.org/10.1016/j.seppur.2013.03.010
11
E Desmidt, K Ghyselbrecht, Y Zhang, L Pinoy, B Van Der Bruggen, W Verstraete, K Rabaey, B Meesschaert. (2015). Global phosphorus scarcity and full-scale P-recovery techniques: a review. Critical Reviews in Environmental Science and Technology, 45(4): 336–384 https://doi.org/10.1080/10643389.2013.866531
B Etter, E Tilley, R Khadka, K M Udert. (2011). Low-cost struvite production using source-separated urine in Nepal. Water Research, 45(2): 852–862 https://doi.org/10.1016/j.watres.2010.10.007
14
J P Gustafsson (2013). Visual MINTEQ. Stockholm, Sweden: Royal Institute of Technology
15
X D Hao, C C Wang, L Lan, M C M van Loosdrecht. (2008). Struvite formation, analytical methods and effects of pH and Ca2+. Water Science and Technology, 58(8): 1687–1692 https://doi.org/10.2166/wst.2008.557
16
H Harada, Y Shimizu, Y Miyagoshi, S Matsui, T Matsuda, T Nagasaka. (2006). Predicting struvite formation for phosphorus recovery from human urine using an equilibrium model. Water Science and Technology, 54(8): 247–255 https://doi.org/10.2166/wst.2006.720
17
C Höglund (2001). Evaluation of Microbial Health Risks Associated with the Reuse of Source-Separated Humna Urine. Dissertation for the Doctoral Degree. Stockholm: Royal Institute of Technology
18
S K L Ishii, T H Boyer. (2015). Life cycle comparison of centralized wastewater treatment and urine source separation with struvite precipitation: focus on urine nutrient management. Water Research, 79: 88–103 https://doi.org/10.1016/j.watres.2015.04.010
19
Y Jaffer, T A Clark, P Pearce, S A Parsons. (2002). Potential phosphorus recovery by struvite formation. Water Research, 36(7): 1834–1842 https://doi.org/10.1016/S0043-1354(01)00391-8
20
D Jeong, C H Lee, S Lee, H Bae. (2020). Nitrification stability and membrane performance under different water permeation intensity of an osmotic membrane bioreactor. International Biodeterioration & Biodegradation, 150: 104962 https://doi.org/10.1016/j.ibiod.2020.104962
21
F Jiang, Y Chen, H R Mackey, G H Chen, M C M van Loosdrecht. (2011). Urine nitrification and sewer discharge to realize in-sewer denitrification to simplify sewage treatment in Hong Kong. Water Science and Technology, 64(3): 618–626 https://doi.org/10.2166/wst.2011.491
22
F Jiang, D H Leung, S Li, G H Chen, S Okabe, M C van Loosdrecht. (2009). A biofilm model for prediction of pollutant transformation in sewers. Water Research, 43(13): 3187–3198 https://doi.org/10.1016/j.watres.2009.04.043
23
I Kabdaşlı, O Tünay, Ç İşlek, E Erdinç, S Hüskalar, M B Tatlı. (2006). Nitrogen recovery by urea hydrolysis and struvite precipitation from anthropogenic urine. Water Science and Technology, 53(12): 305–312 https://doi.org/10.2166/wst.2006.433
24
D Kaelin, R Manser, L Rieger, J Eugster, K Rottermann, H Siegrist. (2009). Extension of ASM3 for two-step nitrification and denitrification and its calibration and validation with batch tests and pilot scale data. Water Research, 43(6): 1680–1692 https://doi.org/10.1016/j.watres.2008.12.039
25
R H Lahr, H E Goetsch, S J Haig, A Noe-Hays, N G Love, D S Aga, C B Bott, B Foxman, J Jimenez, T Luo. et al.. (2016). Urine bacterial community convergence through fertilizer production: storage, pasteurization, and struvite precipitation. Environmental Science & Technology, 50(21): 11619–11626 https://doi.org/10.1021/acs.est.6b02094
26
K S Le Corre, E Valsami-Jones, P Hobbs, S A Parsons. (2009). Phosphorus recovery from wastewater by struvite crystallization: a review. Critical Reviews in Environmental Science and Technology, 39(6): 433–477 https://doi.org/10.1080/10643380701640573
27
S I Lee, S Y Weon, C W Lee, B Koopman. (2003). Removal of nitrogen and phosphate from wastewater by addition of bittern. Chemosphere, 51(4): 265–271 https://doi.org/10.1016/S0045-6535(02)00807-X
28
C Lentner (1981). Units of Measurement, Body Fluids, Composition of the Body, Nutrition. In: Lentner C, ed. Geigy Scientific Tables, 8th ed. Basle: Ciba-Geigy
29
R W Leung, D C Li, W K Yu, H K Chui, T O Lee, M C van Loosdrecht, G H Chen. (2012). Integration of seawater and grey water reuse to maximize alternative water resource for coastal areas: the case of the Hong Kong International Airport. Water Science and Technology, 65(3): 410–417 https://doi.org/10.2166/wst.2012.768
30
H R Mackey, G Rey Morito, T Hao, G H Chen. (2016). Pursuit of urine nitrifying granular sludge for decentralised nitrite production and sewer gas control. Chemical Engineering Journal, 289: 17–27 https://doi.org/10.1016/j.cej.2015.12.071
31
H R Mackey, Y S Zheng, W T Tang, J Dai, G H Chen. (2014). Combined seawater toilet flushing and urine separation for economic phosphorus recovery and nitrogen removal: a laboratory-scale trial. Water Science and Technology, 70(6): 1065–1073 https://doi.org/10.2166/wst.2014.335
32
R Manoharan, S C Harper, D S Mavinic, C W Randall, G Wang, D C Marickovich. (1992). Inferred metal toxicity during the biotreatment of high ammonia landfill leachate. Water Environment Research, 64(7): 858–865 https://doi.org/10.2175/WER.64.7.3
E V Münch, K Barr. (2001). Controlled struvite crystallisation for removing phosphorus from anaerobic digester sidestreams. Water Research, 35(1): 151–159 https://doi.org/10.1016/S0043-1354(00)00236-0
37
E V Musvoto, M C Wentzel, G A Ekama. (2000). Integrated chemical-physical processes modelling-II. Simulating aeration treatment of anaerobic digester supernatants. Water Research, 34(6): 1868–1880 https://doi.org/10.1016/S0043-1354(99)00335-8
38
N O Nelson, R L Mikkelsen, D L Hesterberg. (2003). Struvite precipitation in anaerobic swine lagoon liquid: effect of pH and Mg∶P ratio and determination of rate constant. Bioresource Technology, 89(3): 229–236 https://doi.org/10.1016/S0960-8524(03)00076-2
39
K D Orner, P K Cornejo, Camacho D Rojas, M Alvarez, F Camacho-Céspedes. (2021). Improving life cycle economic and environmental sustainability of animal manure management in marginalized farming communities through resource recovery. Environmental Engineering Science, 38(5): 310–319 https://doi.org/10.1089/ees.2020.0262
40
S Park, W Bae. (2009). Modeling kinetics of ammonium oxidation and nitrite oxidation under simultaneous inhibition by free ammonia and free nitrous acid. Process Biochemistry, 44(6): 631–640 https://doi.org/10.1016/j.procbio.2009.02.002
41
P Reichert. (1995). Design techniques of a computer program for the identification of processes and the simulation of water quality in aquatic systems. Environmental Software, 10(3): 199–210 https://doi.org/10.1016/0266-9838(95)00010-I
42
E W RiceR B BridgeA D EatonL S (2012) Clesceri. StandardMethods for the Examination of Water and Wastewater (22nd ed.). Washington, DC: American Public Health Association
M Ronteltap, M Maurer, R Hausherr, W Gujer. (2010). Struvite precipitation from urine: influencing factors on particle size. Water Research, 44(6): 2038–2046 https://doi.org/10.1016/j.watres.2009.12.015
45
M Salimi, J Heughebaert, G Nancollas. (1985). Crystal growth of calcium phosphates in the presence of magnesium ions. Langmuir, 1(1): 119–122 https://doi.org/10.1021/la00061a019
46
V Smil. (2000). Phosphorus in the environment: natural flows and human interferences. Annual Review of Energy and the Environment, 25(1): 53–88 https://doi.org/10.1146/annurev.energy.25.1.53
47
W T Tang, J Dai, R Liu, G H Chen. (2015). Microbial ureolysis in the seawater-catalysed urine phosphorus recovery system: kinetic study and reactor verification. Water Research, 87: 10–19 https://doi.org/10.1016/j.watres.2015.09.004
48
W Tao, A Bayrakdar, Y Wang, F Agyeman. (2019). Three-stage treatment for nitrogen and phosphorus recovery from human urine: hydrolysis, precipitation and vacuum stripping. Journal of Environmental Management, 249: 109435 https://doi.org/10.1016/j.jenvman.2019.109435
49
W Tao, K P Fattah, M P Huchzermeier. (2016). Struvite recovery from anaerobically digested dairy manure: a review of application potential and hindrances. Journal of Environmental Management, 169: 46–57 https://doi.org/10.1016/j.jenvman.2015.12.006
50
E Tilley, J Atwater, D Mavinic. (2008). Effects of storage on phosphorus recovery from urine. Environmental Technology, 29(7): 807–816 https://doi.org/10.1080/09593330801987145
51
M Türker, I Çelen. (2007). Removal of ammonia as struvite from anaerobic digester effluents and recycling of magnesium and phosphate. Bioresource Technology, 98(8): 1529–1534 https://doi.org/10.1016/j.biortech.2006.06.026
52
K Udert, C Fux, M Münster, T Larsen, H Siegrist, W Gujer. (2003a). Nitrification and autotrophic denitrification of source-separated urine. Water Science and Technology, 48(1): 119–130 https://doi.org/10.2166/wst.2003.0031
53
K M Udert, T A Larsen, M Biebow, W Gujer. (2003b). Urea hydrolysis and precipitation dynamics in a urine-collecting system. Water Research, 37(11): 2571–2582 https://doi.org/10.1016/S0043-1354(03)00065-4
54
K M Udert, T A Larsen, W Gujer. (2003c). Biologically induced precipitation in urine-collecting systems. Water Science and Technology: Water Supply, 3(3): 71–78 https://doi.org/10.2166/ws.2003.0010
55
K M Udert, T A Larsen, W Gujer. (2003d). Estimating the precipitation potential in urine-collecting systems. Water Research, 37(11): 2667–2677 https://doi.org/10.1016/S0043-1354(03)00071-X
56
K M Udert, T A Larsen, W Gujer. (2006). Fate of major compounds in source-separated urine. Water Science and Technology, 54(11−12): 413–420 https://doi.org/10.2166/wst.2006.921
57
M J J M van Kemenade, P L de Bruyn. (1987). A kinetic study of precipitation from supersaturated calcium phosphate solutions. Journal of Colloid and Interface Science, 118(2): 564–585 https://doi.org/10.1016/0021-9797(87)90490-5
58
D P Van Vuuren, A F Bouwman, A H W Beusen. (2010). Phosphorus demand for the 1970–2100 period: a scenario analysis of resource depletion. Global Environmental Change, 20(3): 428–439 https://doi.org/10.1016/j.gloenvcha.2010.04.004
59
J A Wilsenach, C A H Schuurbiers, M C M van Loosdrecht. (2007). Phosphate and potassium recovery from source separated urine through struvite precipitation. Water Research, 41(2): 458–466 https://doi.org/10.1016/j.watres.2006.10.014
60
J A Wilsenach, M C M van Loosdrecht. (2004). Effects of separate urine collection on advanced nutrient removal processes. Environmental Science & Technology, 38(4): 1208–1215 https://doi.org/10.1021/es0301018
61
W Zhang, H Chu, L Yang, X You, Z Yu, Y Zhang, X Zhou. (2023). Technologies for pollutant removal and resource recovery from blackwater: a review. Frontiers of Environmental Science & Engineering, 17(7): 83
